InspectAPedia ^TM

Building & Environmental Inspection, Testing, Diagnosis, Repair, & Problem Prevention Advice

InspectAPedia
Home

Air
Conditioning

Plumbing
Water
Septic

Roofing

Structure

Directory of Professionals to Inspect or Test a Building

FOUNDATION DIAGNOSIS
EARTHQUAKE DAMAGED FOUNDATIONS
FOUNDATION CONSTRUCTION TYPES
FOUNDATION INSPECTION METHODS
FAILURES by FOUNDATION TYPE & MATERIAL
  Block Foundation & Wall Defects
  Brick Foundation & Wall Defects
  Brick Thermal Expansion Cracking
  Concrete Poured Foundation Wall & Slab Defects
  Concrete Pre-cast Foundation Defects
  Stone Foundation Defects
  Wood Foundation Defects
FAILURES by FOUNDATION MOVEMENT TYPE
  BULGED vs. LEANING FOUNDATIONS
  COMBINATIONS OF FOUNDATION MOVEMENT
    Bulge & step cracks
    Earthquake Damage to Foundations
    Flood Damage to Foundations
    Foundation Movement During Collapse
    Other Foundation Step cracks
  HORIZONTAL MOVEMENT IN FOUNDATIONS
    Bulging, Leaning & Sliding Wall
    Horizontal Foundation Creep
    Horizontal Movement & step cracks in brick
    Impact Damage to Foundations
    Thermal Expansion Cracking in Brick
  VERTICAL MOVEMENT IN FOUNDATIONS
    Diagonal Cracks in Concrete Foundations
    Diagonal Step Cracking in Masonry
    Differential vs. Uniform Settlement Cracks
    Leaning or Tipping Buildings
    Uniform Width vs. Tapered Foundation Cracks
    Vertical Cracks
FLOOD DAMAGE TO FOUNDATIONS
FOUNDATION DEFECTS OF OMISSION
FOUNDATION CRACK EVALUATION
  DIAGONAL FOUNDATION CRACKS
  HORIZONTAL FOUNDATION CRACKS
  SHRINKAGE vs EXPANSION vs SETTLEMENT
  Sinkholes & Building Damage
  VERTICAL FOUNDATION CRACKS
FOUNDATION BULGE or LEAN MEASUREMENTS
FOUNDATION DAMAGE SEVERITY
FOUNDATION DAMAGE REPORTS
FOUNDATION INSPECTION STANDARDS
FOUNDATION MOVEMENT ACTIVE vs. STATIC
FOUNDATION REPAIR METHODS
  Bulged foundation Repairs
  Crack Repair Methods
  Horizontal Movement Repairs
  Shrinkage Crack Repairs
  Vertical Movement Repairs
SITE FACTORS AFFECTING FOUNDATIONS
SLAB CRACK EVALUATION
  Control Joint Cracks in Concrete
  Freezing & Water Damage
  Frost Heave/Expansive Soil Cracks in Slabs
  Seal Cracks by Polyurethane Foam Injection
  Seal Cracks in Concrete, How To
  Settlement Cracks in Slabs
  Settlement Cracks vs. Frost Heaves
  Settlement Cracks vs. Shrinkage Cracks
  Shrinkage Cracks in Slabs
  Shrinkage Cracks Along Foundation Walls
  Standards for Repair of Cracks in Floors
WATER ENTRY in BUILDINGS
  SUMP PUMPS GUIDE
ADDITIONAL READING

More Information

InspectAPedia ^TM Home & Site Map
Air Conditioning
InspectAPedia Bookstore
Electrical
Environment
Exteriors
Heating
Home Inspection
Insulate Ventilate
Interiors
Mold Inspect/Test
Roofing
Plumbing Water Septic
Structure
Accuracy & Bias Pledge
Contact Us

How to Inspect, Diagnose, & Repair Concrete Foundation Cracks, Movement, Settlement, Leaks
StructAPedia ^©

Poured Concrete Foundation Defects listed, described & explained

How to identify and evaluate cold pour joints, shrinkage cracks, holes, settlement cracks in foundations

How to identify and diagnose Poured Concrete Foundation Wall & Slab Cracks, Movement, Settlement, Foundation Leaks, & Leans, Bulges, & Other Foundation Defects

Photographs of foundation damage patterns and types

Our site offers impartial, unbiased advice without conflicts of interest. We will block advertisements which we discover or readers inform us are associated with bad business practices, false-advertising, or junk science. Our contact info is at inspect-ny.com/appointment.htm.

Here we discuss How to identify and diagnose Poured Concrete Foundation Wall & Slab Cracks, Movement, Settlement, Leaks, & Other Defects involving reinforced concrete foundations and concrete walls, such as damage due to shrinkage, impact, settlement, frost or water damage, and other causes.

Also see this close companion article: SLAB CRACK EVALUATION which discusses in detail the process of evaluating cracks, settlement, leaks, shrinkage, or other damage in poured concrete slabs, monolithic slab foundations, and concrete floors, and see FOUNDATION CRACK EVALUATION which discusses evaluating foundation damage by examining concrete crack size, shape, pattern, and location.

© Copyright 2008 Daniel Friedman, All Rights Reserved. Information Accuracy & Bias Pledge is at below-left. Use links at the left of each page to navigate this document or to view other topics at this website. Green links show where you are in our document or website.

Examples of structural & other failures in Poured Concrete Foundations: Cracks, Leaks, Movement, & Other Defects

How to Identify Cold Pour Joints in Concrete Foundation Walls

Cold Pour Joints in concrete foundations which leave visible lines in the concrete foundation wall are not usually a structural problem but may in some cases form a dry joint which permits water leakage through the foundation wall.

Cold pour joints occur when there is too much time delay between subsequent "pours" into the foundation forms. An astute inspector, by noting the position, pattern, and slope of the cold pour joint, can probably determine the position from which the concrete was poured into the forms (the high end of the sloping lines) and the extent of delay between pours (evidence of water leaks through the joints indicates that enough time passed for the lower pour to solidify).

Visual clues of cold pour joints give a history of construction sequence and timing: In the photograph above one can just make out the lines of boards used to construct the forms used to pour this foundation wall. The visual clues combine to suggest how this foundation wall was constructed and what happened later. The use of boards and somewhat rough workmanship suggest a "do it yourself" project, perhaps by a small builder or the homeowners themselves. Small contractors or homeowners might rent a cement mixer and mix small batches of concrete, perhaps not even a cubic yard at a time.

Because a fair amount of manual labor would be involved in mixing each small batch of concrete, it's possible that so much time elapsed between concrete pours that the lower pours had cured and hardened so much that subsequent concrete pours did not bond with their predecessors. This (speculative) history might explain why we see horizontal cracks in this concrete wall in a pattern which tracks, almost exactly, the cold pour joint lines in the wall. If the builder also skimped on reinforcing steel or wire in the wall that might be another factor in the development of these cracks in response to earth or frost pressure from outside after the wall was cured.

Where was the concrete truck, how full was it during pouring of the foundation?

The cold pour joints in this concrete foundation wall show us that the concrete truck made the first pour from the corner of this foundation wall. Concrete spread roughly evenly away (and sloping down) from each side of the foundation corner as the concrete was poured into the forms. The truck was probably nearly empty when it started this pour as we don't see much height of concrete below the cold pour joint.

A full concrete truck probably made the second pour as we see no other cold pour joints up to the top of the foundation wall.

This interesting cold pour joint tells us that this wall was poured from its two opposite corners, leaving a vee-shaped cold pour joint in the center of the wall.

Although we can see the dark line between the two concrete pours that formed this wall section, as there was no evidence of an actual crack and no water leakage in the wall, this cold pour joint, like the one above, is not a structural concern - it's cosmetic. Sometimes we can learn something subtle about how a home was constructed and how organized was the builder or mason contractor by observing these clues.

How to Identify Concrete Shrinkage Cracks in Concrete Foundation Walls

Concrete shrinkage cracks are not usually a structural problem but may permit water leaks through the foundation wall. Shrinkage cracks are often mistaken by owners and inspectors who, failing to observe the characteristic discontinuous path of the crack and its meandering path, mistake shrinkage cracks for structural damage.

We discuss shrinkage cracks in great detail and provide diagnostic photographs of shrinkage and other types of concrete cracking in poured concrete floors and slabs at How to Identify and Evaluate Shrinkage Cracks in Poured Concrete and we provide further diagnostic guidance for concrete cracking at SHRINKAGE vs EXPANSION vs SETTLEMENT. The repair of shrinkage cracks (if repair is even needed) is discussed at Shrinkage Crack Repairs.

How to Identify Recognize and Repair Holes and Penetrations in Concrete Foundation Walls

Holes and penetrations in concrete foundations such as poorly-sealed openings left for piping for water or electrical lines or where form ties were broken off may form points of water entry into the structure but are not normally a structural concern.

The "patched" holes shown in this photograph had been a source of chronic leakage and basement water entry since this home had been constructed about two years before this photograph was taken. While several unsuccessful attempts had been made to seal and patch this leak point in the concrete foundation wall, none of the repairs had tried using a suitable product sold for that purpose and the wall was still leaking.

Of course the root problem was that surface water was not being directed away from the building outside. These holes were high enough on the foundation wall that it would be reasonable (and perhaps preferable) to seal the wall from outside before also re-grading to drain surface water away from the building.

How to Identify Settlement Cracks in Concrete Foundation Walls

Concrete foundation settlement cracking such as from footing settlement, absence of or poorly prepared footings, water leading to settlement or actual loss of soils, thus undermining the footings (this can occur and can damage most foundation types), or movement of the foundation due to nearby blasting or excavation work.

Shrinkage cracks in concrete occur only during curing and will appear mostly in the first 28 days after a wall or floor is poured. If cracks noted and documented after this time continue to increase in length or width, some other cause is at work and further investigation is needed.

The concrete settlement crack shown here appeared initially in this wall as a hairline fracture of less than 1/16" in width. The homeowner monitored the crack and watched it increase in width to nearly 1/2" over the following 12 months, leading to the correct inference that there was structural movement going on.

In this case we traced the movement to uneven footing settlement which was aggravated by the combination of having placed the footing partly on bedrock, water from roof and surface spillage and runoff causing soil settlement (the contractor had not compacted the backfill under the footings), and by ongoing foundation blasting at a neighboring lot.

Concrete foundation damage from horizontal loading, vehicles, frost is less commonly seen than with unit-construction materials such as brick or masonry block but might occur under unusual conditions.
Concrete foundation damage from unusual point loads

How to Identify Form Tie Marks and Leak Points in Concrete Foundation Walls

Photograph of water entry leaks at concrete form ties

Concrete Foundation Form Tie leaks: Leaks at the location of concrete form ties used during construction of a poured concrete foundation are not normally a structural problem but they can be blamed for basement water entry.

Form tie leaks occur in a poured concrete foundation wall where the form ties used to construct the foundation have left penetrations in the concrete walls.

Form ties are wire or steel connections between the two vertical sides of the wood or steel concrete form. Concrete form ties are needed to prevent the forms from separating and bulging from the weight of the concrete poured into the form. The best solution to concrete wall form tie leaks is to keep water away from the foundation from outside.

Other Types of Foundation Damage to Concrete Walls or Floors

Leaning concrete foundation walls or structural walls due to: water, frost, or earth loading, vehicle passage too close to the wall, inadequate footings, soil undermining
Concrete foundation wall cracks*: settlement, shrinkage, cold joints
Concrete foundation spalling due to poor concrete mix, too much water, excessive working of the surface, pouring during cold weather without proper additives, roof runoff rain-splash erosion of the wall surface.

Repair of Foundations

For detailed information about foundation repair methods, including repairs to various kinds of cracks in concrete, see:

FOUNDATION REPAIR METHODS for our catalog of Foundation Repair Methods - Examples of Typical Foundation Repairs for various types of foundation cracks, leaks, settlement, movement, or other failures
How to Seal Cracks in Concrete
Shrinkage Crack Repairs
Polyurethane Foam Injection for details of the procedure for using polyurethane foam to seal foundation cracks.
Cracks at Control Joints in Concrete how we prevent shrinkage cracks in poured concrerte floors and walls

SHRINKAGE vs EXPANSION vs SETTLEMENT
Evidence of Foundation Shrinkage
Evidence of Foundation Expansion
Foundation Settlement: crack patterns, other evidence

FOUNDATION DIAGNOSIS Chapter Index

Use links just below or at the left of each page to navigate this document or to view other topics at this website. Green links show where you are in our document or website.

FOUNDATION DIAGNOSIS - how to inspect and diagnose foundation problems, in-depth diagnosis, and evaluation of all types of structural and non-structural cracks in residential foundations [Brick, Concrete, Masonry Block, Stone]
EARTHQUAKE DAMAGED FOUNDATIONS - examples of earthquake-damaged building foundations
FOUNDATION CONSTRUCTION TYPES - identify different foundation types, construction materials, effects of sequence of construction
FOUNDATION INSPECTION METHODS - what to look for when inspecting any building foundation
FAILURES by FOUNDATION TYPE & MATERIAL- unique failure characteristics of each foundation material
  Block Foundation & Wall Defects
  Brick Foundation & Wall Defects
  Brick Thermal Expansion Cracking
  Concrete Poured Foundation Wall & Slab Defects
  Concrete Pre-cast Foundation Defects
  Stone Foundation Defects
  Wood Foundation Defects
FAILURES by FOUNDATION MOVEMENT TYPE -recognize & diagnose types of foundation damage by the nature of foundation movement
  BULGED vs. LEANING FOUNDATIONS - distinction of foundation bulging from foundation leaning has important implications for stability
  COMBINATIONS OF FOUNDATION MOVEMENT - the real world of foundation cracks and movement: often more than one force is at work
    Bulge & step cracks
    Earthquake Damage to Foundations
    Flood Damage to Foundations
    Foundation Movement During Collapse
    Other Foundation Step cracks
  HORIZONTAL MOVEMENT IN FOUNDATIONS - detection, causes, effects, evaluation of horizontal or lateral foundation movement; hillsides
    Bulging, Leaning & Sliding Wall
    Horizontal Foundation Creep
    Horizontal Movement & step cracks in brick
    Impact Damage to Foundations
    Thermal Expansion Cracking in Brick
  VERTICAL MOVEMENT IN FOUNDATIONS - detection, causes, effects, evaluation of vertical foundation movement, differential settlement
    Diagonal Cracks in Concrete Foundations
    Diagonal Step Cracking in Masonry
    Differential vs. Uniform Settlement Cracks
    Leaning or Tipping Buildings
    Uniform Width vs. Tapered Foundation Cracks
    Vertical Cracks
FLOOD DAMAGE TO FOUNDATIONS - examples of flood damaged foundations, flood damage case analysis: were these cracks due to flooding?
FOUNDATION DEFECTS OF OMISSION - recognize things that were left out, like footings, reinforcement, soil compaction, during foundation construction
FOUNDATION CRACK EVALUATION- recognize & diagnose types of foundation cracks, movement, damage, by the size, shape, location, pattern of cracks
  DIAGONAL FOUNDATION CRACKS - causes and significance of diagonal foundation cracks, varies by foundation type & material
  HORIZONTAL FOUNDATION CRACKS - causes and significance of horizontal foundation cracks, varies by foundation type & material
  SHRINKAGE vs EXPANSION vs SETTLEMENT - which foundation materials shrink, which expand, & their characteristic crack patterns
  Sinkholes & Building Damage - sinkhole recognition, significance, cause, underlying geology, areas where sinkholes are worst
  VERTICAL FOUNDATION CRACKS - - causes and significance of vertical foundation cracks, varies by foundation type & material
FOUNDATION BULGE or LEAN MEASUREMENTS - procedure for documenting the amount of lean or bulge in a foundation or other building wall
FOUNDATION DAMAGE SEVERITY - rules of thumb for deciding how much foundation movement requires further action
FOUNDATION DAMAGE REPORTS - how to report foundation inspection results and damage
FOUNDATION INSPECTION STANDARDS - definition of scope of what a foundation inspector
FOUNDATION MOVEMENT ACTIVE vs. STATIC - determine if foundation movement was a one-time event or an ongoing problem
FOUNDATION REPAIR METHODS - catalog of methods used to repair damaged foundations and masonry building walls
  Bulged foundation Repairs
  Crack Repair Methods
  Horizontal Movement Repairs
  Shrinkage Crack Repairs
  Vertical Movement Repairs
SITE FACTORS AFFECTING FOUNDATIONS - drainage, rock, soil compaction, slope or grading, bedrock, sloping bedrock, proximity to roads
SLAB CRACK EVALUATION - recognize and diagnose different types of slab or concrete floor cracks and movement
  Control Joint Cracks in Concrete - what are control joints, why they are needed, what happens when they're omitted; are they structural?
  Freezing & Water Damage - recognize frost and water damage to concrete slabs, distinguish from other crack types
  Frost Heave/Expansive Soil Cracks in Slabs - distinguish between frost damage and expansive clay soil damage to slabs
  Seal Cracks by Polyurethane Foam Injection - stop basement or crawl space leakage
  Seal Cracks in Concrete, How To - products and methods used to seal or repair cracks in poured concrete walls, foundations, floors, & slabs.
  Settlement Cracks in Slabs - recognize slab settlement, assess risk, assess potential impact on structure
  Settlement Cracks vs. Frost Heaves - how to tell the difference between frost heaves and foundation settlement; does it matter?
  Settlement Cracks vs. Shrinkage Cracks - critical identification of shrinkage cracks (non-structural) compared with foundation movement
  Shrinkage Cracks in Slabs - causes, prevention, assessment of concrete slab shrinkage cracks
  Shrinkage Cracks Along Foundation Walls - why do we see a gap between a poured concrete slab and its abutting foundation wall?
  Standards for Repair of Cracks in Floors - when does a floor or slab crack need to be repaired? why?
WATER ENTRY in BUILDINGS
  SUMP PUMPS GUIDE - how a sump pump can avoid foundation damage and reduce building water entry
ADDITIONAL READING

Technical Content Reviewers for Foundation Crack and Movement Damage Evaluation, Diagnosis, & Reporting

Daniel Friedman - ASHI (1986-2006) - author of this website and article, building failures researcher.
"Concrete Slab Finishes and the Use of the F-number System", Matthew Stuart, P.E., S.E., F.ASCE, online course at www.pdhonline.org/courses/s130/s130.htm
Sal Alfano - Editor, Journal of Light Construction*
Thanks to Alan Carson, Carson Dunlop, Associates, Toronto, for technical critique and some of the foundation inspection photographs cited in these articles
Terry Carson - ASHI
Mark Cramer - ASHI
JD Grewell, ASHI
Duncan Hannay - ASHI, P.E. *
Bob Klewitz, M.S.C.E., P.E. - ASHI
Ken Kruger, P.E., AIA - ASHI
Aaron Kuertz aaronk@appliedtechnologies.com, with Applied Technologies regarding polyurethane foam sealant as other foundation crack repair product - 05/30/2007
Bob Peterson, Magnum Piering - 800-771-7437 - FL*
Arlene Puentes, ASHI, October Home Inspections - (845) 216-7833 - Kingston NY
Greg Robi, Magnum Piering - 800-822-7437 - National*
Dave Rathbun, P.E. - Geotech Engineering - 904-622-2424 FL*
Ed Seaquist, P.E., SIE Assoc. - 301-269-1450 - National
Dave Wickersheimer, P.E. R.A. - IL*
*These reviewers have not returned comment 6/95

Use links at the left of each page to navigate this document or to view other topics at this website. Green links show where you are in our document or website.

More Information on Building Diagnostic Inspections and Repairs

FOUNDATION CRACK EVALUATION discusses detail the process of evaluating foundation cracks and signs of foundation damage by examining the crack size, shape, pattern, and location.
FOUNDATION BULGE or LEAN MEASUREMENTS explains a simple method for determining how much bulge or lean is present in a foundation or wall,
FOUNDATION MOVEMENT ACTIVE vs. STATIC helps determine if the foundation movement is ongoing,
FOUNDATION DAMAGE SEVERITY discusses how we decide the severity of foundation damage and the urgency of further action.
FAILURES by FOUNDATION TYPE & MATERIAL describes the types of foundation damage, cracks, leaks, or other defects associated with each type of foundation material (concrete, brick, stone, concrete block, etc.).

InspectAPedia ^TM Home & Site Map - Building Inspection, Diagnosis, & Repair, Environmental Inspection & Testing - Research Website

The Mold Information Center: What to Do About Mold in Buildings, When and How to Inspect for Mold, Clean Up Mold, or Avoid Mold Problems

GO TO our PRE PURCHASE BUILDING INSPECTION SERVICES: Authoritative information for home buyers and home owners is included with your inspection. Home Inspection Construction Consulting Services & advice for home buyers

CONTACT Daniel Friedman - Dan is a senior ASHI home inspector, nationally recognized expert on building inspection, building failures, and sick building investigation Contact Daniel Friedman for website content suggestions or for fee-paid consulting

InspectAPedia TM

How to Inspect, Diagnose, & Repair Concrete Foundation Cracks, Movement, Settlement, LeaksStructAPedia ©